|
|
Mubychem Group, established in 1976, is the pioneer manufacturer of Zinc Chloride, Ammonium Chloride, Calcium Chloride, Potassium Chloride, Sodium Acetate, Sodium Thiosulphate, Methylene Blue, Pharmaceutical, Fragrance & Flavor chemicals in India. Mubychem Group has several manufacturing facilities spread across Western India. |
For Translating this page in your language use this translation tool (Refresh if the tool is not seen). |
--------
--------
Methylene Blue MSDS; Manufacturers
Buy Methylene Blue;
Door Delivery
Methylene Blue USP BP IP ACS FCC; Methylene Blue Manufacturers
Methylene Blue
Technical & Pure Crystals, Methylthionium
Chloride
Also IP BP Ph. Eur. USP ACS AR LR FCC Food Grades
Methylene Blue MSDS Sheet, Material safety Data Sheet
1. Product IdentificationSynonyms: Basic Blue 9,trihydrate;
Methelyne blue
trihydrate; 3,7-Bis(dimethylamino)phenazathionium
chloride trihydrate
CAS No.: 61-73-4 (Anhydrous); 7220-79-3 (Trihydrate)
Molecular Weight: 373.91
Chemical Formula: C16H18ClN3S .
3H2O
2. Composition/Information on Ingredients
Ingredient: Methylene BlueCAS No.: 61-73-4
Percent: 100%
3. Hazards Identification
Emergency OverviewMethylene Blue is relatively non-hazardous in routine industrial situations.
Potential Health Effects
Inhalation: No adverse health effects expected from inhalation. May cause a short period of rapid or difficult breathing.
Ingestion: A burning sensation of the mouth may be noted following ingestion of methylene blue. May cause nausea, vomiting, diarrhea, and gastritis. Large doses may cause abdominal and chest pain, headache, profuse sweating, mental confusion, painful micturation, and methemoglobinemia.
Skin Contact: Not expected to be a health hazard from skin exposure. Methylene blue may color the skin a bluish color. May cause photosensitization.
Eye Contact: No adverse effects expected. May cause mechanical irritation.
Chronic Exposure: No information found.
Aggravation of Pre-existing Conditions: No information found.
4. First Aid Measures
Inhalation: Remove to fresh air. Give oxygen if breathing is difficult; give artificial respiration if breathing has stopped. Keep person warm and quiet; get medical attention.Ingestion: Induce vomiting immediately as directed by medical personnel. Never give anything by mouth to an unconscious person.
Skin Contact: Immediately flush skin with plenty of soap and water for at least 15 minutes. Remove contaminated clothing and shoes. Wash clothing before reuse. Thoroughly clean shoes before reuse. Get medical attention if irritation develops.
Eye Contact: Immediately flush eyes with plenty of water for at least 15 minutes, lifting upper and lower eyelids occasionally. Get medical attention.
5. Fire Fighting Measures
Fire: Methylene blue is considered to be a fire hazard.Explosion: Not considered to be an explosion hazard.
Fire Extinguishing Media: Use any means suitable for extinguishing surrounding fire.
Special Information: In the event of a fire, wear full protective clothing and NIOSH-approved self-contained breathing apparatus with full face piece.
6. Accidental Release Measures
Ventilate area of leak or spill. Wear appropriate personal protective equipment. Pick up spills and place in a suitable container for reclamation or disposal, using a method that does not generate dust.7. Handling and Storage
Keep Methylene Blue in a tightly closed container, stored in a cool, dry, ventilated area. Protect against physical damage. Avoid dust formation and control ignition sources. Isolate from incompatible substances. Containers of Methylene Blue may be hazardous when empty.8. Exposure Controls/Personal Protection
Airborne Exposure Limits: None established.Ventilation System: In general, dilution ventilation is a satisfactory health hazard control for this substance. However, if conditions of use create discomfort to the worker, a local exhaust system should be considered.
Personal Respirators (NIOSH Approved): Not expected to require personal respirator usage. For conditions of use where exposure to dust or mist is apparent and engineering controls are not feasible, a particulate respirator (NIOSH type N95 or better filters) may be worn. If oil particles (e.g. lubricants, cutting fluids, glycerin, etc.) are present, use a NIOSH type R or P filter. For emergencies or instances where the exposure levels are not known, use a full-face positive-pressure, air-supplied respirator.
Skin Protection: Wear protective gloves and clean body-covering clothing.
Eye Protection: Use chemical safety goggles and/or full face shield where dusting or splashing of solutions is possible. Maintain eye wash fountain and quick-drench facilities in work area.
9. Physical and Chemical Properties
Appearance: Methylene Blue is dark green crystals with bronze luster or crystalline powder.Odor: Odorless.
Solubility: Soluble in water.
Specific Gravity: No information found.
pH: No information found.
% Volatiles by volume @ 21C (70F): 0
Boiling Point: Decomposes.
Melting Point: 100 - 110C (212 - 230F)
Vapor Density (Air=1): 13
Vapor Pressure (mm Hg): Not applicable.
Evaporation Rate (BuAc=1): No information found.
10. Stability and Reactivity
Stability: Methylene Blue is stable under ordinary conditions of use and storage.Hazardous Decomposition Products: May produce oxides of nitrogen, sulfur and carbon when heated to decomposition.
Hazardous Polymerization: Will not occur.
Incompatibilities: Strong oxidizing agents, alkali, dichromates, alkali iodides, reducing agents.
Conditions to Avoid: Heat, flame, ignition sources, dusting and incompatibles.
11. Toxicological Information
Methylene Blue: 1180 mg/kg LD50 oral rat. Investigated as a mutagen, reproductive effector.--------\Cancer Lists\---------------------------------------------------------
-------------------------------- NTP Carcinogen---
Ingredient -------------------Known -- Anticipated IARC Category
----------------------------- -------- ------------ -------------
Methylene Blue(61-73-4) ---- No -------- No ------------- None
12. Ecological Information
Environmental Fate: When released into the soil, this material is not expected to evaporate significantly. When released into water, this material is not expected to evaporate significantly. This material has an estimated bioconcentration factor (BCF) of less than 100. This material is not expected to significantly bioaccumulate. When released into the air, this material is expected to be readily degraded by reaction with photochemically produced hydroxyl radicals. When released into the air, this material may be removed from the atmosphere to a moderate extent by wet deposition. When released into the air, this material may be removed from the atmosphere to a moderate extent by dry deposition.Environmental Toxicity: No information found.
13. Disposal Considerations
Whatever cannot be saved for recovery or recycling should be managed in an appropriate and approved waste disposal facility. Processing, use or contamination of this product may change the waste management options. Dispose of container and unused Methylene Blue in accordance with legal requirements.14. Transport Information
Not regulated.15. Regulatory Information
--------\Chemical Inventory Status - Part 1\---------------------------------Ingredient TSCA EC Japan Australia
------------------------- ----- ----- ----- -------
Methylene Blue (61-73-4) Yes Yes Yes Yes
--------\Chemical Inventory Status - Part
2\-----------------------------------Canada--
Ingredient
Korea DSL
NDSL Phil.
-------------------------------------
-----
--- ----
-----
Methylene Blue (61-73-4)
Yes
Yes No
Yes
--------\Federal, State & International Regulations - Part
1\----------------
-SARA 302- ------SARA 313------
Ingredient
RQ TPQ List
Chemical Catg.
---------------------------------
--- -----
---- --------------
Methylene Blue (61-73-4)
No No
No
No
--------\Federal, State & International Regulations - Part
2\----------------
-RCRA- -TSCA
Ingredient
CERCLA 261.33
8(d)
---------------------------------
------ ------
------
Methylene Blue (61-73-4)
No
No
No
SARA 311/312: Acute: Yes Chronic: No Fire: No Pressure: No Reactivity: No (Pure / Solid)Australian Hazchem Code: None allocated.
Poison Schedule: None allocated.
EINECS: This product is on the European Inventory of Existing
Commercial Chemical Substances.
WHMIS (Canada): Not controlled under WHMIS (Canada).
DSCL (EEC): R36/38- Irritating to eyes and skin.
HMIS (U.S.A.):
Health Hazard: 2
Fire Hazard: 1
Reactivity: 0
Personal Protection: E
National Fire Protection Association (U.S.A.):
Health: 2
Flammability: 1
Reactivity: 0
Specific hazard:
Protective Equipment:
Gloves. Lab coat. Dust respirator. Be sure to use an approved/certified
respirator or equivalent. Splash goggles.
16. Other Information
Disclaimer:***************************************************************************************************
Our company provides this Methylene Blue MSDS information contained herein in good faith but makes no representation as to its comprehensiveness or accuracy. This Methylene Blue MSDS sheet is intended only as a guide to the appropriate precautionary handling of the material by a properly trained person using this product. Individuals receiving the information must exercise their independent judgment in determining its appropriateness for a particular purpose.
***************************************************************************************************
Methylene Blue Manufacturers:
MUBY CHEMICALS
S-8, SARIFA MANSION, 2ND FLANK ROAD,
CHINCHBUNDER, MUMBAI 400009, INDIA
TEL: (OFFICE) 91-22-23770100, 23726950,
23774610, 23723564. FAX: 91-22-23728264
e-mail:
info@mubychem.com
Cell Call
to Anmol: +91-9821870100
USA & Canadian Customers may Call
773-829-5811
Copyright and Usual Disclaimer is
Applicable.
Last updated
01 December, 2011
----------------
| Old Spice: Manufacturing since more than Three Decades: | |||
|
Best Selling IP BP USP FCC ACS Grades of Chemicals by Anmol Chemicals |
|||
| Borax; Sodium Borate | |||
| BP Calcium Chloride Dihydrate BP | |||
| Chromic Chloride | |||
| Manganese Chloride | Manganese Sulfate | Methylene Blue | Potassium Chloride |
| Sodium Acetate | Sodium Hydroxide | Sodium Thiosulfate | |
| Zinc Chloride | |||
|
Pharmaceuticals & Food Grade, IP BP USP FCC ACS Gr. of Chemicals mfd. by Anmol Chemicals |
|||
| Sodium Citrate | Titanium Dioxide | ||
| Zinc Carbonate | |||
| Aluminum Ammonium Sulfate Manufacturers |
|
||
Global or International Methylene Blue BP USP... Suppliers, Exporters, Importers, Manufacturers
Exports to USA UAE Europe Africa Tanzania Kenya Uganda Egypt Turkey Brazil Chile Argentina Dubai etc.
----------------
Methylene Blue is also
called ( CAS No. 548-62-9; 603-47-4 )
Basic blue 9 (C.I.
52015)
3,7-Bis-(dimethylamino)-phenazathonium chloride
3,7-Bis-(dimethylamino)-5-phenothiazinium chloride
C.I. 52015
Methylene blue (C.I. 52015)
Methylthionine chloride
Solvent blue 8 (C.I. 52015)
Swiss blue
Tetramethylthionine chloride
Urolene blue